Panduit Net-Contain Installation Manual download pdf (Page 32)

For Technical Support: www.panduit.com/resources/install_maintain.asp

INSTALLATION INSTRUCTIONS

V00029BZ

Page 32 of 124

692mm

(27.25”)

Length of

containment

system

(measured from

inside of posts)

Center of

Contained Aisle

Detail A

32mm

(1.26”)

Containment System Layout

• The containment system length is measured from inside of posts, as shown below.

• The drill layout shown below applies to all aisle widths (900mm, 1200mm, and 1800mm).

(6) 8mm (5/16")

Clearance Holes

150mm

(5.9")

150mm

(5.9")

30mm

(1.18")

Detail A

1 2 ... 27 28 29 30 31 32 33 34 35 36 37 ... 123 124

INSTALLATION INSTRUCTIONS 1
V00029BZ 1
Page 2 of 124 2
Page 3 of 124 3
Page 4 of 124 4
Page 5 of 124 5
Page 6 of 124 6
Page 7 of 124 7
Page 9 of 124 9
C2HACERI1626** 10
C2HACERI2638** 10
C2HACERI3866** 10
Page 12 of 124 12
Table of Contents 13
Page 14 of 124 14
SECTION 1 16
(For 900mm 42RU Set-Up Only) 17
(For 900mm 45RU Set-Up Only) 18
(For 900mm 48RU Set-Up Only) 19
(For 900mm 52RU Set-Up Only) 21
Attaching Hanger to Post 25
Containment System Layout 32
Attaching Post to Floor 34
Install Post Foot Cover 35
Attaching End of Row Beam 36
Attaching Support Hanger 42
Attaching Support Bracket 43
SECTION 2 49
Attaching Wall Beam Connector 51
Securing Wall Beam 58
Attaching Roofing Beam 62
Installing Wall Beam Clamp 63
SECTION 3 65
Roofing Aisle 66
Placing Ceiling Panel 67
Securing Ceiling Panel 69
.5"x.75" 74
Foam Seal 74
Installing Vertical Wall 75
Setting Wall Panel Height 76
Sizing Upper Seal 77
Attaching Upper Seal 78
Attaching Foam to Lower Seal 79
Attaching Lower Seal 80
SECTION 5 81
Attaching Lower Side Frame 82
Attaching Lower Cross Beams 83
Attaching Upper Cross Beams 84
Attaching Upper Side Frame 86
Attach Center Cross Beams 87
Attach Center Frames 88
Measure and Cut Wall Panel 92
Insert Wall Panel 95
Foam Seal Installation 97
SECTION 6 98
Attaching Transom 99
Flap Seal Installation 100
Attaching Door Guides 105
Header Installation 106
Left Hand Sliding Door Set-Up 108
Sliding Door Installation 109
Adjusting Sliding Door Height 110
Adjusting Door Seals 111
Adjusting Door Damper 112
Attaching Cover Caps 113
Header Cover Installation 114
SECTION 7 115
Cutting Blanking Panels 116
Placing First Lower Guide 117
Additional Lower Guides 118
Blanking Panel Installation 119

Comments to this Manuals

No comments

Panduit Net-Contain Installation Manual Page 32

Comments to this Manuals